As we were travelling around Australia in 2013 as brand new Grey Nomads, we took advantage of 'Free Camping' as much as possible. However, much to our surprise, we ran out of water on two occasions, despite having two water tanks on board. We were always mindful of this limited resource and rationed it accordingly.
I determined there and then, that something must be done, so it wouldn't happen again.
Getting bigger water tanks wasn't an option, so when we got home after our 5 month trip, I started researching the hows and whys of procuring clean, safe water for drinking, while on the road.
What I came up with may not be the best way, or even the only way, but for us… it worked!
I had read that others had pumped 'clean water' from creeks and rivers, to top up their water tanks, but without adequate filtering and purification, I felt this would be too risky.
My solution was, to build a pump, filtration and purification system that would produce clean, potable water from practically any water source (except salt water).
The D.I.Y Project consisted of:
- An inexpensive plastic toolbox from Bunnings, to house the pump and battery.
- A 40 AmpHour AGM battery to power the pump, rather than running long leads from the van.
- A 5w Solar Panel to keep the battery charged.
- At water's edge, the water is pumped from the creek or river, through a sediment filter, to an activated carbon block filter, through a final carbon/silver filter to...
- A Holding Tank (a 20 litre food grade bucket) and then
- Purified by the addition of Katadyn Micropur Silver Ion powder.
After two hours, the purified water is pumped into the caravan water tanks, via a bilge pump setup in the 'holding tank'.
It is now suitable for showering, washing and drinking.
For peace of mind more than anything, we have a ceramic/carbon filter installed under the sink, to produce pure drinking water.
With this setup, we can procure water from creeks, rivers, billabongs... and in a pinch, even horse troughs and puddles!
The photos that follow, tell the story.
The PARTS List:
- Toolbox $19.95 Bunnings
- Water Pump $79 eBay
- Battery $95 eBay
- Solar Panel $38 eBay
- Sediment/Carbon Filter Unit $78 eBay
- B.E.S.T. Filter $100
- Food Grade Bucket $14 Bunnings
- Bilge Pump $16 eBay
- 3 x 10m Drinking Water Hoses $57 Bunnings
- Misc. switches, fuses, wiring... $20
- Katadyn Micropur Powder $150
- Doulton Ceramic/Carbon Filter $76
Approximate total cost $743.00
I had everything except the Tool Box, Battery, Solar Panel, Micropur Powder and Doulton Ceramic Filter. So when you consider the tens of thousands we spend on a caravan and tow vehicle, an extra few hundred to guarantee never running out of water again... the exercise is worthwhile!